Designed to work on merchant and fishing vessels as the main engine, and large vessels as vspomogoatelnogo diesel generator as a source of electricity.
technical characteristics
Designation of a diesel engine in accordance with GOST 4393-74 - 6CHSP 18/22
Rated power under normal conditions *, kW (hp)
- On the shaft of a diesel engine, 110.4 (150)
- At the outlet flange DRD 104.8 (142.5)
Maximum power (short-term, not more than 1 hour) on the shaft of the diesel engine under normal conditions, kW (hp) 121.44 (165)
Maximum power of the total operating time of the diesel engine,%, not more than 10
Repetition maximum power is not more than, Part 5
Rated speed, s-1 (r / min) 12.5 (750)
Maximum speed, s-1 (r / min) 12.8 (772)
Minimum sustained speed, s-1 (r / min)
- Idling 5 (300)
- With screw harahteristiki under load of 4.1 kW (5.5 hp) 4.15 (250)
When the length of continuous work hours, not more than
- Idling 0.5
- Under a load of 2
* Intake air temperature of 293 K (20 ° C), relative humidity of 70%, barometric pressure of 101.3 kPa (760 mm Hg) vacuum at the intake 1,962 kPa (200 mm Hg) pressure on the release of 3 44 kPa (350 mm. Hg), the temperature of the seawater at the entrance to the cooler 305 K (32 ° C)
Number of cylinders 6
Operating procedure of cylinders (when counting the cylinders of a station)
- The left engine DD03 1-4-2-6-3-5
- The right engine DD04 1-5-3-6-2-4
The direction of rotation of the crankshaft (flywheel side)
- For the left engine DD03 clockwise
- For the right engine DD04 counterclockwise
The maximum combustion pressure at maximum power under normal conditions, kPa (kgf / cm2) not more than 6370 (65)
System pressure gidrozapora nozzles at 750 / min, kPa (kgf / cm2) 14,700 ± 981 (150 ± 10)
Fuel supply timing angle in degrees of crankshaft rotation of 22 ± 2
The temperature of the circulating water at the output of the diesel engine, K (0C) 358 (85)
Specific oil consumption, g / kWh (g / e.l.s.ch)
- To burn 1.22 (0.9)
- A total of 1.71 (1.26)
- Oil on M-10G2TSS 1.59 (1.17)
Oil temperature at the outlet of a diesel engine, R (0C), no more than 353 (80)
Timing of the suction valve, hail
-Opening BTDC 7 - 12
Close, after BDC 27 - 32
Timing of the exhaust valves, hail
-Opening up BDC 27 - 32
Close, ATDC 7 - 12
Reverse gear factory designation 27RRP-230
Type of reverse-reduction gear mechanical misalignment, with two conical friction clutches and gears front and rear moves
Models levobortnaya, pravobortnaya
gear ratio
- To move forward, i = 1: 1.67; i = 1: 2.14
- Astern i = 1: 2
Speed at which produces switching on and off DRD-1 (r / min), no more than 7.5 (450)
Time reversal, with not more than 15
Duration of work in reverse is not limited
Resource diesel and DRS before the first overhaul, hours 50000
mechanisms diesel
Additional clutch PTO - PTO at 750 r / min and turned off RRP, kW (hp), not more than 29.4 (40)
Fuel pump - gear, performance (at 375 rev / min, discharge pressure 49 kPa (0.5 kgf / cm2) and a suction lift of 1 m), l / min 1.5
Oily pump - gear, performance (at 1125 rev / min and a pressure of 588 kPa discharge (6 kgf / cm2), l / min 76.6
Oily Filter partially-line - two reactive centrifuge capacity (at 6 kgf / cm2 and an oil temperature of 70 0C), l / min 10
Shestiplunzherny fuel pump, block
Fuel filter 2TF-3
Linkki venäjänkieliseen Wikiin: https://ru.wikipedia.org/wiki/6_%D0%A7%D0%9D_18/22#cite_note-Spring-1
Ei kommentteja:
Lähetä kommentti